<var id="gpqzg"></var>
<dfn id="gpqzg"></dfn>

<rp id="gpqzg"><thead id="gpqzg"></thead></rp>

  1. <b id="gpqzg"><address id="gpqzg"></address></b>
      <delect id="gpqzg"></delect><acronym id="gpqzg"><thead id="gpqzg"><tr id="gpqzg"></tr></thead></acronym>

        <var id="gpqzg"><td id="gpqzg"><object id="gpqzg"></object></td></var>
        歡迎來到山東創杰智慧裝備科技有限公司,我們竭誠為您服務
        伸縮移動噴漆房非標定制設計要點
        來源:http://www.hnbjyygs.com/ 發布時間:2023-11-27

        設計時要考慮消除靜電.因噴漆房給排風過濾系統的過濾棉多為化纖制品,在給風和排塵過程中過濾材料會聚集很多的粉塵,在風機的動力下由于摩擦會產生較多的靜電放電現象,如沒有靜電消除裝置很容易引起火災和爆炸.室外排塵風管如果高出建筑物高度時,還應考慮采取避雷措施。

        When designing, consideration should be given to eliminating static electricity. As the filter cotton used in the air supply and exhaust filtration system of the paint spraying room is mostly chemical fiber products, the filtering material will accumulate a lot of dust during the air supply and dust removal process. Under the power of the fan, friction will generate more static electricity discharge phenomena. Without static electricity elimination devices, it is easy to cause fires and explosions. If the outdoor dust exhaust duct is higher than the height of the building, lightning protection measures should also be considered.

        在設計漆房的照明時對選用的燈具開關需要防爆,以免在開啟時發生危險

        When designing lighting for paint rooms, explosion-proof switches are required for the selected lamps to avoid danger when turned on

        對排塵風機需要選用防爆風機,同時還應考慮風機的噪聲不能達標

        Explosion proof fans need to be selected for the dust removal fan, while also considering that the noise of the fan cannot meet the standard

        在滿足工藝要求的前提下盡量要選用經濟適用型給排風的風機,同時要求給風風機的給風量要比排風風量大10%,以確保漆房微正壓。

        Under the premise of meeting the process requirements, it is advisable to choose economical and suitable fans for air supply and exhaust. At the same time, it is required that the air supply volume of the fan should be 10% higher than the exhaust volume to ensure a slight positive pressure in the paint room.

        在制作安裝時要按設計要求去作,避免隨意更改圖紙,以_漆房的安裝質量。

        When making and installing, it is necessary to follow the design requirements and avoid making arbitrary changes to the drawings_ The installation quality of the paint room.

        給排風系統的過濾器及漆霧凈化器要定期清理,以防對系統的操作環境造成破壞,需要建立健全相關的維護保養制度,并設專人負責。

        The filters and paint mist purifiers of the exhaust system should be cleaned regularly to prevent damage to the operating environment of the system. It is necessary to establish a sound maintenance system and assign a dedicated person to be responsible.

        工廠在使用移動伸縮噴漆房時,有許多的注意事項,只有了解了這些注意事并能這些規則,這樣才提高移動式噴漆房工作效率,不會發生故障:

        There are many precautions when factories use mobile retractable paint spraying rooms. Only by understanding these precautions and following these rules can the efficiency of mobile paint spraying rooms be improved and no malfunctions occur:

        由于噴漆設備是屬于的特殊設備,所以需要落實專人負責開啟關閉和運行巡視。

        20230531091455583.jpg

        Due to the fact that spray painting equipment is a special type of equipment, it is necessary to assign a dedicated person to be responsible for opening, closing, and conducting operational inspections.

        對干式噴漆房過濾下來的固體廢物和濕式漆房過濾下來的廢渣廢水需要經過妥善處理,避免二次污染。

        The solid waste filtered from the dry paint booth and the waste residue and wastewater filtered from the wet paint booth need to be properly treated to avoid secondary pollution.

        伸縮房操作人員,應該定期檢查伸縮噴漆房限位開關的靈敏度,同時每隔三個月檢查一次聯動機構和減速機傳動機構是否正常,還有緊固螺栓不得有松動現象。而關于噴漆房減速機及軸承部分,潤滑要良好同時還要注意保護排風機機箱的日常保潔。

        The operator of the telescopic room should regularly check the sensitivity of the limit switch in the telescopic spray painting room, and check the linkage mechanism and reducer transmission mechanism every three months to ensure they are normal, and the fastening bolts should not be loose. Regarding the gearbox and bearings in the paint booth, good lubrication is necessary while also paying attention to the daily cleaning of the exhaust fan casing.

        伸縮移動前室軌道附近不能有雜物,并禁止向噴漆房內部投擲異物

        There should be no debris near the track of the retractable front chamber, and it is prohibited to throw foreign objects into the interior of the paint booth

        有了伸縮式噴漆房上面的小總結,希望對廣大客戶有所幫助,如果有什么不理解的或者尋求幫助的請點擊我們的網站:http://www.hnbjyygs.com或者來電咨詢,我們會盡全力為您解決

        With the summary on the retractable spray booth, we hope it can be helpful to our customers. If you have any questions or need help, please click on our website: http://www.hnbjyygs.com Or call to inquire, we will do our best to solve it for you

        上一篇:汽車噴烤漆房過濾系統及相關維護
        下一篇:多工位焊煙除塵設備的使用說明

        • 服務熱線: 18563723072
        • 官方微信
        在线观看一级毛片免费,亚洲一区二区约美女探花,欧美在线免费,日韩在线二区全免费